Technical method for preparing high nutritious feed by using straw fermentation agent

Straw fermented feed involves the use of microbial inoculants, such as the Kinpo straw fermenting agent, to process crop straws. These microorganisms and enzymes break down the straws into a soft, moist, and bulky texture with a slightly sour smell that is highly appealing to livestock like cattle and sheep. The fermented feed produced by Beijing Huaxia Kangyuan Technology Co., Ltd. not only enhances the nutritional value of the feed but also lowers breeding costs while promoting the full utilization of agricultural resources. This makes it an excellent project worth adopting and promoting.

The production method using the golden bait straw starter includes the following steps:

1. Preparation of raw materials: The straw should be cut or crushed into small pieces or strands depending on the type of animal. For cows, horses, and quail, the straw should be chopped into 1-2 cm pieces. Sheep and deer require about 1 cm pieces, while pigs, chickens, ducks, geese, and rabbits need the straw finely ground.

2. Mixing the ingredients: Use 1 kg of the golden bait straw fermenting agent for every 500 pounds of straw. First, dissolve the starter in warm water (30-35°C) and mix thoroughly. In summer, cold water can also be used. Then, mix this solution well with the prepared straw material. The moisture content should be around 60-70%. To check if the moisture is right, grab a handful of the mixture—no water should drip from your fingers. The general ratio of straw to water is approximately 1:1.5.

3. Piling up the mixture: After mixing, pile the straw material into a heap with a height of 40-50 cm. Place a thermometer inside the pile and cover it with a heat-insulating and moisture-retaining material to start the fermentation process.

4. Temperature control: Fermentation usually takes 6-8 hours in summer and 16-24 hours in winter when the temperature is above 15°C. If the ambient temperature is below 15°C, try to raise the temperature to at least 15°C. Using insulation measures on the pile can speed up the process.

5. Turning the pile: Once the temperature reaches 40°C, the pile should be turned once. Make sure the temperature doesn’t exceed 45°C, as this could lead to over-fermentation. It’s recommended to turn the pile 1-2 times during the entire process. When the straw turns yellow and emits a pleasant aroma, the fermentation is complete. At this point, remove the covering, let it cool, and avoid any secondary fermentation that might cause re-heating.

Veterinary APIs

Veterinary APIs (active pharmaceutical ingredients) refer to the raw materials or substances used in the production of veterinary drugs. These APIs are the key components that provide the therapeutic effect in veterinary medications. They are typically sourced from various suppliers and undergo strict quality control measures to ensure their safety and efficacy for use in animals.

Some common examples of veterinary APIs include antibiotics, antiparasitics, hormones, vaccines, and anti-inflammatory agents. These APIs are used to treat a wide range of conditions in animals, including infections, parasites, hormonal imbalances, and inflammatory diseases.

It is important for veterinary pharmaceutical companies to carefully select and source high-quality APIs for their products to ensure the safety and effectiveness of the medications. Regulatory authorities also closely monitor the production and use of veterinary APIs to ensure compliance with safety and quality standards.

We can supply and customize Veterinary Medicine that customer requiry like Albendazole/Amprolium
TOLTRAZURIL/Closantel Sodium/Doxycycline HCL/IVERMECTIN/TILMICOSIN PHOSPHATE/CARBASALATE CALCIUM/Erythromycin Thiocyanate/Oxytetracycline HCl/Tylosin tartrate/FLORFENICOL/Sulfadiazine/Sulfadimidine/Sulfadimidine Sodium/Cefotaxime sodium/Ceftriaxone sodium/Aspirin/Milbemycin Oxime/ Cefotaxime sodium/Colistin sulfate/Ceftiofur hydrochloride/Bromhexine Hcl/ Colistin Sulphate/etc

Veterinary Apis Drug,Veterinary medicine raw materials,Veterinary Apis Medicine,Bulk drug,bulk pharmaceutical

NANYANG CHENGPENG PHARMACEUTICAL CO.,LTD , https://www.chppharm.com

Posted on